Fieldbus System

P P P P P P P P SY5000 P P P P P P P P SY5000 P P P P C2 C3 C4 C6 C8 CM N1 N3 N7 N9 CM 2 One-touch fitting 1/8" One-touch fitting 3.2 One-touch fitting 5/32" One-touch fitting P P P P P P P P P P P P P P Straight Elbow Straight Elbow 4 One-touch fitting 1/4" One-touch fitting 6 One-touch fitting 5/16" One-touch fitting 8 One-touch fitting Straight port, mixed sizes LN3 LN7 LN9

Air Fittings & Tubing

D P M Part No.

KJ

P. 34 P. 34 KQ2L T KQ2T P. 34 KQ2H Use to branch line from female thread in both 90 directions. VMG Branch Y Male run tee Gasket Use to branch line in the same direction from female thread and in 90 direction. KQ2U KQG P. 35 P. 35 KQ2Y P. 36 Use to branch line in the same direction from female thread.

2/3 Port Valve

R P A Energized closed (N.O.) R P A Common (C.O.)

I

ZS-22-A H O W T O O R D E R P O S I T I V E P R E S S U R E S W I T C H S E R I E S ISE4 H O W T O O R D E R V A C U U M P R E S S U R E S W I T C H S E R I E S ZSE4 PANEL MOUNTING KIT ZS-22-A ZSE4B ISE4 B O P E R AT I N G P R E S S U R E O P T I O N S -0.1 ~ 1MPa L -10 ~ 100KPa Non-Backlit (Standard) B Backlit LCD O P T I O N S P I P I N G S P E C I F I C AT I O N S Non-Backlit (Standard

VQ7-6/7-8

(Values at the initial period) 1 (P) 5 (R1) 3 (R2) 1 (P) 5 (R1) 3 (R2) 3 position pressure center (A) 4 (B) 2 1 (P) 5 (R1) 3 (R2) 3-10-7 8 Series VQ7-6 DIN Terminal Type 2 position single : VQ7-6-FG-S single (Reverse pressure): VQ7-6-YZ-S 120.5 120.5 68.5 52 68.5 Mounting hole 2-6.5 50 50 42.5 42.5 25 25 13 (A port) 13 (B port) Manual override (R1, R2) 2-3/8 P R2 R1 A B 14 11 50 62 12 9 62

VM

. 5-6-8 Series VM100 P . 5-6-12 Series VM200 P . 5-6-20 Series VM400 P . 5-6-26 Series VZM500 P . 5-6-41 Series VZM400 P . 5-6-35 Series VFM300 P . 5-6-48 Series VFM200 P . 5-6-54 Series VFM800 P . 5-6-32 Transmitters Page Relay Valve P . 5-7-1 Shuttle Valve P . 5-7-3 Shuttle Valve with One-touch Fitting P . 5-7-5 AND Valve with One-touch Fitting P . 5-7-7 Time Delay Valve P . 5-7

Rubber seal 5 Port Solenoid Valve Series SYJ5000

(P) (B) 2 (A) 4 3 position exhaust center (A) 4 (B) 2 5 (R1) 3 (R2) 1 (P) 3 position pressure center (A) 4 (B) 2 i 5 (R1) 1 (P) 3 (R2) 5 (R1) 3 (R2) 1 (P) (This figure shows a closed center type.)

Vacuum Pad

P #Vacuum Ejector or Pump and Number of Vacuum Pads Ejector and number of pads Vacuum pump and number of pads Vacuum line Tank P P P P P P P P P Ideally, one pad should be used for each line. When more than one pad is attached to a single vacuum line, take the countermeasures listed below.

LEC-OM02704CN

P-D 1 P P C C G3 D (2) 1) G4 5m (1) 1.

High Vacuum Angle Valve, XL Series

P.4 to P.7 XLAV (With solenoid valve) Particulate free completely cleaned Bellows Seal 105 to 10-6 10-10 10-11 2 XLC Double acting P.8 to P.11 XLCV (With solenoid valve) Manual Electromagnetic Air operated XLF Single acting (N.C.)

XL

P.4 to P.7 XLAV (With solenoid valve) Particulate free completely cleaned Bellows Seal 105 to 10-6 10-10 10-11 2 XLC Double acting P.8 to P.11 XLCV (With solenoid valve) Manual Electromagnetic Air operated XLF Single acting (N.C.)

OMR0031

Controller Set Up (P.34) and 14. Card Motor Controller Configuration software (P. 57) for instructions on how to setup. (6) Test operation Refer to section 10. Monitor and Test Mode of the Controller (P.41) and 14.5 Monitor/Test window (P. 68) for instructions on operating instruction of test operation 14 - 3.

2/3 Port Valve

Water Air Oil Low vacuum (1 Torr) Coolant Steam Applicable fluid 1 8 1 4 3 8 1 2 3 4 Rc(PT) 1 Port size 1 4 1 1 2 1 2 32A 40A 50A Flange 65A 80A Page P.4.2-3 to P.4.2-10 P.4.2-11 to P.4.2-18 P.4.2-19 to P.4.2-27 P.4.2-28 to P.4.2-34 P.4.2-35 to P.4.2-42 4.2-2 2 Port Valve for Comressed Air and Air-hydro Circuit Control Process Valve SeriesVNA Universal 2 Port Valve Exclusively for air pressure

Prevents Micro-Bubbles

Single type Suck back P P P VN A B A B Unit Single type Unit LVC Manifold (5 stations max.) LVA LVH A R P 3 port N.C. PA LVD N.C.

JXCx-OMT0005CN

(P.23) 10.1 (P.33) 3.4 (P.16) 11.(P.42) (CN1: EMG 3.(P.12) ) INP ON 10.1 (P.33) (INP PLC ) 5 3.(P.12) PLC (PLC) 2 12.4 (P.50) 11.(P.42) 3.(P.12) 83 - 5.(P.23) 10.1 (P.33) 3.(P.12) PLC (PLC) 2 12.4 (P.50) () () (LED() 3.2 (P.13) ) 11.(P.42) 5 11.(P.42) 11.(P.42) 3.(P.12) (CN1: EMG 3.

3 Port Solenoid Valve Metal Seal/Rubber Seal Body Ported VQZ100/200/300

Resin Body SYJ (A) 2 Aluminum/NBR Spool valve w Pilot valve VK e 1 (P) 3 (R) VQZ100-12A Resin/Aluminum P, R plate r r VZ VT VQZ200/300 VT Metal seal Rubber seal VP r e w q r e w q VG VP VQ VQZ N.C. N.C. VZ (A) 2 (A) 2 VS 3 (R) 1 (P) 3 (R) 1 (P) r e w q r e w q N.O. N.O. (A) 2 (A) 2 3 (R) 1 (P) 3 (R) 1 (P) Component Parts Material Description Notes No.

7.4

S07B5 4(A) 2(B) 5(R1) 3(R2) 1(P) 5 (R1) 4 (A) 1 (P) 2 (B) 3 (R2) y t N.O. + N.O. Component Parts S07C5 2(B) No.

Thermo-chiller/Rack Mount Type

Mounted p. 34 Air-cooled Refrigeration (Single-phase 100/115 VAC) p. 13 With Feet/Without Rack Mounting Brackets p. 35 Water-cooled Refrigeration (Single-phase 100/115 VAC) p. 13 Removed Parts p. 35 HRR012/018/024/030 How to Order VOptional Accessories Air-cooled Refrigeration (Single-phase 200 to 230 VAC) p. 14 qConcentration Meter p. 36 Water-cooled Refrigeration (Single-phase

Vacuum

Panel mounl adapter H i s h-p reci s io n D i s *"l?